Failsafe galvanic isolator
10Pages

FaîlSafe 30 and 60 Amp Galvanic Isolators Owner's Manual and Installation Guide For 30 Amp Shore Cord Applications I For(1)50 Amp or(2)30 Amp Shore Cord Applications Certified by ULto ABYC A-28 Released 7-31-2008, CE, Ignition Protected Part No. Shore Cord Inlet Compatibility Ratings VAC/MAX. AMPS/Hz IMPORTANT NOTICE This manual contains important safety and operating instructions for the 30 (Part Number 22034) and 60 amp (Part Number 22074) FS Series Galvanic Isolators. Please save and read all safety, operating, and installation instructions before installing or connecting to the green wire. Please visit our website at www.promariner.com for any warranty, service or installation assistance and FAQ's or cal our Customer Care Department at 800-824-0524 from 8:30 am to 5 pm (Eastern Time). PLEASE RECORD YOUR: Model Number;_

Product Overview... Safety Instructions... Installation Guidelines... Customer Service and Warranty... ► Why You Need a FailSafe Galvanic Isolator_ It is very important that while a vessel is at the dock, plugged into shore power, that the bonding system be electrically connected to earth. Without this connection the chance is increased that, through accident or failure in the electrical distribution system or in AC electrical equipment aboard the boat, the bonding system could become electrically "HOT" (presence of 110 or 220 VAC). An occurrence of this type could quickly become deadly...

Safety Instructions Note: These Galvanic Isolators include a capacitor in the circuit providing Galvanic Isolation. This capacitor will prevent stray AC current sometimes present on the AC ground wire from defeating the purpose of the Galvanic Isolator. Please note the below locations of important safety labels. ELECTRICAL SHOCK HAZARD. FAILURE TO PROPERLY INSTALL SHOULD BE MOUNTED IN AN AREA WHERE AMBIENT DOES NOT COULD RESULT IN SERIOUS INJURY OR DEATH. EXCEED 50*0. IT IS NOT NECESSARY TO GROUND THE CASE. ^\ CAUTION THIS DEVICE DOES NOT PROVIDE ASTATUS MONITOR. FOLLOWING ALIGHTNING...

Installation Guidelines Single 30 Amp /120 Volt Inlet Shore Cable Connector Green Main breaker Dual 30 Amp/120 Volt Inlet Shore Cable For 2 - 30 amp shore cords - see ABYC E-11 for exact wire size to use. For 1 - 50 amp shore cord - see ABYC E-11 for exact wire size to use.

Installation Guidelines Single 50 Amp /220 - 250 Volt Inlet Bulkhead Connector Shore Cable Main breaker

Troubleshooting & Maintenance CAUTION - Because of the presence of deadly high voltages, troubleshooting the FS Galvanic Isolator should be done by qualified service personnel only. I.Turn off the AC panel main breaker. 2. Unplug all shore chords. 3. Remove all green wires from the Galvanic isolator. 4. With a multimeter in the DIODE TEST POSITION ) place the first test probe on one stud and the second probe on the second stud. Hold the test probes in place for approximately 1 minute; the meter will typically display .800 to 1.00. Reverse the test probes; hold for 1 minute or until the...

Customer Service & Warranty ► Customer Service & Warranty We are committed to customer satisfaction and value yourbusiness.lt at anytime during the warranty period you experience a problem with your ProSafe Galvanic Isolator simply call us at 1 -800-824-0524 or email info@promariner.com for technical support. WARRANTY CARD CAN BE REGISTERED ATWWW.PR0MARINER.COM or the warranty card included in this manual can be completed and sent to ProMariner by mail. FAIL SAFE SERIES GALVANIC ISOLATOR FIVE YEAR WARRANTY WITH LIMITED LIFETIME REPLACEMENT POLICY Each ProSafe model is guaranteed against...

►Visit ProMariner Online at www.promariner.com, for a Complete Selection of Quality Marine Products... ► ProMite Series - Standard Edition Waterproof Marine Battery Chargers ► ProSport Series - Recreational Sport Fishing & Boating Waterproof Marine Battery Chargers ► ProTournament Series - Professional Grade Tournament Waterproof Marine Battery Chargers ► Advanced 4 Step Dry Mount Marine Battery Chargers i ProSport Cup Holder Inverters ► TruePower Marine Inverters 200-3000 Watts ► Corrosion Control Products ► Waterproof Marine Binoculars ► Gold Plated Fuses and Holders ► A Complete Line of...